國內外酒店餐飲業、休閑旅游業等行業的高速發展，酒店布草洗滌行業為剛性需求。下面小編來分享
酒店布草洗滌的工序流程，如下：
The rapid development of industries such as hotel catering and leisure tourism at home and abroad has made the hotel linen washing industry a rigid demand. Below, the editor will share the process flow of hotel linen washing, as follows:
分類
classification
對布草按顏色、面料、污漬的輕重進行分類。
Classify linen according to color, fabric, and the severity of stains.
預洗
Pre washing
把分類好的布草以洗缸容積的80%裝缸，加入中水位清洗2-3分鐘，使污垢得到溶解，先洗去部分水溶性污垢，隨水排掉。
Fill the sorted linen with 80% of the washing capacity and add it to the medium water level for 2-3 minutes to dissolve the dirt. First, wash off some water-soluble dirt and drain it with water.
主洗
Main washing
預洗后把水排掉，加水至中水位，加入清洗原料。根據布草狀況，調好水溫，浴衣80℃左右，床單、巾類、餐臺布草類80-85℃左右，進行加強清洗，這樣可以提高洗滌劑與污垢所產生的化學作用和速度，起到消毒和殺菌的作用。
After pre washing, drain the water, add water to the medium level, and add cleaning materials. According to the condition of the linen, adjust the water temperature to around 80 ℃ for bathrobes, and around 80-85 ℃ for bed sheets, towels, and tabletop linen. Strengthen cleaning to improve the chemical reaction and speed of detergent and dirt, and play a role in disinfection and sterilization.
漂白
bleach
此過程是主洗去污的補充步驟，主要去除主洗步驟中不能完全去掉的色素類污垢。在這個步驟中主要使用氧化性漂白劑（氧漂粉）。因此在操作中應嚴格控制水溫在65℃～70℃，而且要控制洗液pH值在10.2～10.8，同時根據污垢類型及織物結構嚴格控制好投放量。
This process is a supplementary step to the main washing and decontamination process, mainly removing pigmented dirt that cannot be completely removed during the main washing step. In this step, oxidizing bleach (oxygen bleaching powder) is mainly used. Therefore, during operation, the water temperature should be strictly controlled between 65 ℃ and 70 ℃, and the pH value of the washing solution should be controlled between 10.2 and 10.8. At the same time, the dosage should be strictly controlled according to the type of dirt and fabric structure.
漂洗
Rinsing
主洗后把水排掉，加入高水位進行清洗，即兩遍排水，兩遍中脫直到布草上的洗滌劑清洗干凈。
After the main wash, drain the water and add a high water level for cleaning, that is, drain twice and remove in the middle until the detergent on the cloth is clean.
中和酸、柔順
Neutralize acid and soften
布草漂洗后，布草上面會含有部分殘留洗滌劑，所以加入中和酸、柔順劑，洗至4-5分鐘，進行高脫，使布草在使用時更加光澤，柔順。
After rinsing the cloth, there will be some residual detergent on the cloth, so add neutralizing acid and softener, wash for 4-5 minutes, and perform high stripping to make the cloth more shiny and smooth when in use.
燙平、烘干、整理
Ironing, drying, and organizing
對清洗后的布草，理順分別放入采用高溫蒸汽的燙平機，進行熨燙，溫度一般在230℃左右，烘干機里面進行烘干，溫度一般在85℃左右。
After cleaning the linen, place it in a high-temperature steam ironing machine for ironing, with a temperature generally around 230 ℃. The dryer is used for drying, with a temperature generally around 85 ℃.
注意事項：
matters needing attention:
1.氧漂劑和洗滌劑配合使用，如使用氯漂劑，先將布草浸泡后再使用，避免布草接觸強酸堿性和腐蝕性的化學品。
1. When using oxygen bleach and detergent together, if chlorine bleach is used, soak the cloth first before use to avoid contact with strong acid, alkali, and corrosive chemicals.
2.頑固污漬處理方法：頑固污漬先用40℃溫水加相應的去污劑浸泡1-2小時。
2. Treatment method for stubborn stains: Soak stubborn stains in 40 ℃ warm water and corresponding detergent for 1-2 hours.
3.彩色布草禁止使用氯漂劑。
3. The use of chlorine bleach is prohibited for colored linen.
4.熨燙和烘干至100%干燥（正常使用中的布草干燥度80%左右），防止長期存放出現布草發黃發霉現象。
4. Iron and dry the cloth to 100% dryness (the dryness of the cloth in normal use is about 80%) to prevent yellowing and moldy phenomenon of the cloth during long-term storage.
That's all for the process flow of hotel linen washing. I hope the explanation will be helpful to you. For more details, please come to us http://m.xcnmpx.com Consultation and understanding!
您當前位置: 
